The Talking Machine Forum — For All Antique Phonographs & Recordings

It is currently Sun Jun 24, 2018 8:03 pm

All times are UTC - 5 hours [ DST ]




Post new topic Reply to topic  [ 4 posts ] 
Author Message
 Post subject: Original Varnish Transfers c1930 Instructions for use
PostPosted: Fri Jan 05, 2018 9:46 am 
Offline
Victor IV
Joined: Mon May 13, 2013 2:04 pm
Posts: 1209
Varnish Transfers


Original Varnish Transfers c1930 Instructions for use

1) Apply a thin coat of Varnish to the wood that the transfer is to be fixed on.

2) When the Varnish has become tacky place the entire transfer in the required position. ( If only part of the transfer is required the transfer can easily be cut and altered , from the front picture which is aligned exactly to the transfer behind )

3) Allow Varnish to set overnight.

4) Remove thick outer protective paper to reveal thin rice paper underneath.

5) Soak the rice paper in tepid water for a few minutes and then remove the rice paper revealing the transfer.

6) Varnish over the transfer to protect it. ( Before varnishing the transfers can be darkened with wood stain and also "aged" if required using very fine wire wool )

* steps 1 to 3 can be replaced with care by applying an adhesive to the back of the transfer covering the whole of the aluminium foil backing, and placing in position, allow the adhesive to set and then go to step 4 , this adhesive procedure is illustrated by the group of transfer pictures shown below


1) aluminium foil back to the transfer



2) Coat the aluminium foil evenly and thinly with adhesive



3) Place transfer in position allow the adhesive to set for a while ( Depending on the type of adhesive used ) and peel off thick outer paper



4) This reveals the thin absorbent rice paper underneath



5) Soak the the rice paper in tepid water




Remove the rice paper to expose the transfer in place



6) The transfer can now be varnished over to protect it

to see the pictures go to http://soundgenpics8.blogspot.co.uk/200 ... sfers.html


Top
 Profile  
 
 Post subject: Re: Original Varnish Transfers c1930 Instructions for use
PostPosted: Thu Jan 11, 2018 8:58 am 
Offline
Victor III
User avatar
F. Depero, "Grammofono", 1923.
Joined: Thu Feb 24, 2011 4:19 am
Posts: 692
Location: Italy
Mike, what do you mean exactly with "varnish"? Shellac in alcohol? I ignore if decals where made with different materials back then, however, in my experience, decals are melted/destroyed by any kind of solvent. There is a vast literature about what to do in order to preserve them, if they have to be covered by a protective layer of transparent paint/varnish/enamel. Nothing works well in every case, and even specific products used in model crafting are prone to give problems quite often.


Top
 Profile  
 
 Post subject: Re: Original Varnish Transfers c1930 Instructions for use
PostPosted: Thu Jan 11, 2018 12:06 pm 
Offline
Victor VI
I have good days...this might not be one of them
Joined: Wed Jan 07, 2009 5:23 pm
Posts: 3759
Location: Albany NY
Marco Gilardetti wrote:
Mike, what do you mean exactly with "varnish"? Shellac in alcohol? I ignore if decals where made with different materials back then, however, in my experience, decals are melted/destroyed by any kind of solvent. There is a vast literature about what to do in order to preserve them, if they have to be covered by a protective layer of transparent paint/varnish/enamel. Nothing works well in every case, and even specific products used in model crafting are prone to give problems quite often.


a Varnish Decal is made in an entirely different way than the typical water slide decal & is intended to be sealed under a finish.


Top
 Profile  
 
 Post subject: Re: Original Varnish Transfers c1930 Instructions for use
PostPosted: Fri Jan 12, 2018 5:05 am 
Offline
Victor III
User avatar
F. Depero, "Grammofono", 1923.
Joined: Thu Feb 24, 2011 4:19 am
Posts: 692
Location: Italy
Well, I hope so... ;)

I still have to come across a "varnish decal", however. Whenever I needed to use a reproduction decal, whatever the item for which the decal was inteded, it was always, solely and invariably a water decal.


Top
 Profile  
 
Display posts from previous:  Sort by  
Post new topic Reply to topic  [ 4 posts ] 

All times are UTC - 5 hours [ DST ]


Who is online

Users browsing this forum: No registered users and 1 guest


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Search for:
Jump to:  
Powered by phpBB © 2000, 2002, 2005, 2007 phpBB Group
Americanized by Maël Soucaze.